Physical Address
304 North Cardinal St.
Dorchester Center, MA 02124
NOTE-Pumps and cylinders purchased from Convertible Top Specialists may be filled with fluid, this fluid will either be Dextron III automatic transmission fluid or mineral hydraulic oil.
How do you fill a hydraulic fluid for a convertible top?
How do you fill a convertible fluid?
Just insert the specially tapered nozzle into your reservoir filling hole, then run the top up and down. In about five minutes the air in the system will be replaced with fresh hydraulic fluid.
Is a cabrio and Cabriolet the same?
It might interest you to know that cabriolet is the source of the cab name for taxis. When people refer to a convertible as a cabriolet, they often shorten the name to Cabrio.
What is hydraulic fluid made from?
mineral oil Today most hydraulic fluids are based on mineral oil base stocks. Natural oils such as rapeseed (also called canola oil) are used as base stocks for fluids where biodegradability and renewable sources are considered important.
How do you test a convertible top motor?
Use a digital multimeter to check the lines feeding the convertible top motor. Every time you press the convertible switch, you should read between 11-13 volts at the pump. If you are not getting any current at the hydraulic motor, you may have an electrical problem or a defective switch.
Why won’t my convertible top go down?
If a convertible top simply doesn’t go up or down when you engage the switch, the cause may be a bad fuse, lift cylinder, or relay. When a convertible top gets stuck in the process, it is most likely caused by a lift cylinder or a broken cable.
Can convertible top cylinders be rebuilt?
Upgrading your convertible top cylinders, pumps & hoses without compromise. Top Hydraulics rebuilds convertible top cylinders and pumps, making them better than new inside, resulting in optimized performance and much longer service life!
How do you put oil in a convertible top motor?
How do you close the top on a convertible Mustang?
How do you close the roof on a Mini Cooper?
What does Cabrio mean in English?
The word cabrio is the short form of the word cabriolet. The word is of French origin and historically referred to a light one-horse carriage with a folding leather hood. Nowadays, the term is most often used to refer to any convertible car with a folding hood.
Why are convertibles called cabriolet?
Convertible. The word cabriolet has a French origin that was derived back in the 1800’s that referred to a horse-drawn carriage with two wheels and a top that could be pulled over the two occupants of the carriage when weather became bad. …
When was VW Cabrio made?
As a result, when the Beetle was replaced by the first-generation Golf known as the Rabbit in the United States in 1976, Volkswagen wanted to design a new compact, affordable convertible built with safety in mind. The result hit the U.S. market in 1980 as the Volkswagen Rabbit Cabriolet.
What are the three types of hydraulic fluid?
Three common varieties of hydraulic fluids found on the market today are petroleum-based, water-based and synthetics.
- Petroleum-based or mineral-based fluids are the most widely used fluids today. …
- Water-based fluids are used for fire-resistance due to their high-water content.
Can you mix different brands of hydraulic fluid?
CAN I MIX HYDRAULIC FLUIDS? As far as possible, it is always best to avoid mixing different hydraulic fluids. This is because the technical properties could be spoiled by chemical reactions between different additives.
Is there a difference between hydraulic oil and hydraulic fluid?
Hydraulic oil and hydraulic fluid are terms that are sometimes used interchangeably, but they are not necessarily the same. While hydraulic oil is a fluid, hydraulic fluid can also consist of other fluids, including plain water, water-oil emulsions and salt solutions.
How do I know if my convertible top motor is bad?
Symptoms
- Slow convertible top movement – If your convertible top moves slowly, it could be due to several reasons. …
- Convertible top won’t raise or lower – The convertible pump is not getting power, or it is not working. …
- Beck lid won’t open – Bad limit switch. …
- Convertible top won’t go down – Bad relay.
How much does it cost to replace a convertible top motor?
Most of the time, you will have to replace your convertible roof motor at the same time you replace your top. The typical convertible roof motor will cost you anywhere between $150 to $300 for the partial, and between $100 to $200 for the labor.
How do you manually close a convertible top?
Closing The Top Manually
- Remove passengers from the car. …
- Locate the convertible top storage lid behind the back seat head rests. …
- Reach into the opened compartment and lift up on the convertible frame. …
- Press down on the convertible top storage lid to close it all the way.
Are convertibles slower?
Because the roof is a critical part of a car’s structure, convertibles need extra bracing to stiffen their bodies. As a result, they typically are hundreds of pounds heavier and a bit slower than their hardtop counterparts.
Can you replace a convertible top with a hardtop?
If you want a permanent replacement for your convertible top, Smooth Line has you covered. Since 1959, our quality removable Hardtops have been enjoyed by many thousands of sport car enthusiasts. For a simple, permanent solution, you just can’t beat a Smooth Line Hardtop.
How does a convertible top motor work?
The convertible motor drives the pump which is connected to the motor at one end and the fluid reservoir on the other end. The pump generates a pressure varying from 300 to 450 psi. It is fitted in the trunk area and supplies hydraulic fluid to the lift cylinders which are mounted on either side of the vehicle.
What is hydraulic technology?
Hydraulics (from Greek: ) is a technology and applied science using engineering, chemistry, and other sciences involving the mechanical properties and use of liquids. … In its fluid power applications, hydraulics is used for the generation, control, and transmission of power by the use of pressurized liquids.